July 10, 2010 in Nation/World

BP gets OK to replace well cap

If it’s successful, effort could finally halt flow of oil
Mark Seibel McClatchy
 

WASHINGTON – In a dramatic turn of events, the Obama administration has given BP the go-ahead to remove the containment cap atop the runaway Deepwater Horizon oil well and replace it with a tighter fitting one in an attempt to stop all the oil now flowing into the Gulf of Mexico, perhaps as soon as the middle of next week.

If successful, no oil would gush into the Gulf of Mexico for the first time since soon after the Deepwater Horizon exploded in flames on April 20.

Thad Allen, the Obama administration’s point man on the oil spill, said Friday that the current containment cap will be removed today and that installation of the new one would begin three or four days later.

Once the new cap is in place, engineers will attempt to stop any oil from flowing out.

“Our first goal,” Allen said of the new containment device, “would be to shut … the well in. In other words, close all the means of oil to escape.”

It was unclear how, after more than 80 days, officials suddenly had a seeming solution to the gushing oil ready in such a short period of time.

Allen didn’t say how many days it would be before the cap would be in place, but a timeline that BP provided to Allen on Friday shows that if all things go as planned, BP would be able to close off the well five days after the old containment cap is removed.

If technicians encounter difficulties, that period might stretch to nine days, the timeline showed.

Bob Dudley, the BP executive in charge of the Gulf oil spill, said in a letter to Allen that included the timeline that switching the containment cap wouldn’t begin until hoses are connected that would allow BP to add a third ship to collect oil from the blown-out well.

Allen, however, appeared satisfied that those preparations are well on the way to completion and that engineers “will likely be in a position to be able to start removing the current cap … tomorrow.”

Just Wednesday, Allen had declined to lay odds on whether the Obama administration would approve the new containment cap, and Thursday he remained skeptical that BP would be able to close off the well until mid-August.

Allen laid the decision to the weather, saying forecasters are predicting a seven- to 10-day window of calm weather.

“We think this weather window presents a significant opportunity for us to accelerate the process of capping – shutting down the well from the top and increasing the prospects for being able to kill the well from below through the relief wells,” Allen said.

Allen also said other events had come together to assuage earlier concerns that capping the well at the top would cause damage to the well itself – a concern that caused officials to halt the so-called “top kill” effort in late May.

“If there is a problem and we have to release the pressure … there’ll be four different ways to take (crude out) … and produce it,” lessening the pressure.

Allen described a multi-step process of robots unscrewing six bolts to remove the sheared-off riser pipe, strapping together two pipes that will remain so it’s easier to fit the containment cap over them, then bolting the new contraption in place and sealing it with a valve.

There are, of course, no guarantees.

For one, while Allen talked of seven to 10 days of calm weather, BP’s timeline shows only an eight-day window – a window just barely long enough to accommodate the work if unbolting the well’s riser pipe takes longer than the ideal.

BP also provided Allen with a list of backup plans should the new containment cap take longer to install than anticipated or not work as officials hope.

Among those, Dudley wrote, would be the stationing between the Deepwater Horizon site and the Gulf Coast of nearly 400 boats and more than 50 aircraft that would be expected to spot and scoop up the additional oil that would flow into the Gulf between the time the current containment cap is removed and the time the new one is installed.

The primary backup plan, however, is the completion of connections that would allow oil to flow from the Deepwater Horizon well’s failed blowout preventer directly to the Helix Producer I drill ship. Those connections are in place, Allen said, and the Helix producer may begin receiving oil as soon as Sunday.

Get stories like this in a free daily email


Please keep it civil. Don't post comments that are obscene, defamatory, threatening, off-topic, an infringement of copyright or an invasion of privacy. Read our forum standards and community guidelines.

You must be logged in to post comments. Please log in here or click the comment box below for options.

comments powered by Disqus